waypointjobs

Blue Origin

Senior Thermal Engineer – Constellations

merritt island, FL

Check who can apply and the requirements below before continuing.

This job is closed

Applications are no longer available for this announcement. Explore current related opportunities below.

Job description

Special Mentions

Location: This role can be based at any of the following Blue Origin locations: Denver, CO; Los Angeles, CA; Space Coast, FL; Reston, VA; Huntsville, AL; or Kent, WA (Seattle area).

Relocation: Relocation assistance is available for candidates relocating to one of the primary Blue Origin office locations.

Travel: Up to 25% travel may be required depending on work location and program needs.

Responsibilities Include But Are Not Limited To

Lead thermal design & analysis for satellite-based, high-power payloads and associated power electronics.

Develop detailed thermal models using tools such as Thermal Desktop, SINDA/FLUINT, or equivalent, covering conduction, radiation, and convection regimes as appropriate.

Define and manage thermal interfaces across payload subsystems, including radiators, heat pipes, loop heat pipes, cold plates, and structural elements.

Perform transient and steady-state thermal analyses to validate performance under mission profiles, including peak duty cycles, eclipse transitions, and worst-case environmental conditions.

Develop thermal architecture for common bus/payload configurations reused across a production block, including tailoring for orbit plane, beta angle range, and payload variant.

Select and defend the appropriate thermal qualification, margin, and acceptance approach (e.g., protoflight, workmanship-only TVAC on subsequent units, thermal cycling screening, lot acceptance sampling) based on build rate, mission class, and design life; tailor requirements per SMC-S-016 / MIL-STD-1540 as applicable.

Define thermal model correlation strategy under limited test data, extending correlated models across the rest of a production block.

Address LEO thermal cycling fatigue over high cycle counts (~5,000+ eclipse cycles/year) on joints, solder, TIMs, and coatings across design life.

Drive design-for-manufacturability of thermal hardware at rate (e.g., MLI touch labor, coating repeatability, TIM dispensing, heater and thermostat installation), leveraging parametric or automated thermal modeling workflows to support rapid trades.

Evaluate COTS or commercial-grade thermal components where mission class permits, and manage heater power budget as a fleet-level EPS driver, trading heater sizing against battery and array mass.

Support design-for-demise and material selection for disposal casualty risk (ODMSP).

Assess manufacturability, cost, and schedule impact of thermal hardware choices (radiators, heat pipes, loop heat pipes, cold plates) for production at scale.

Support thermal design and analysis concurrently across multiple constellation and payload programs, prioritizing effort against shifting schedules and design maturity.

Collaborate closely with payload subject matter experts, mechanical, power, and systems engineering teams to ensure thermal constraints are integrated into payload element layout and packaging.

Establish thermal requirements, margins, and verification plans aligned with mission reliability and lifetime goals.

Drive thermal design trades balancing performance, mass, power consumption, manufacturability, and cost for both space and ground systems.

Contribute to major technical design reviews and serve as a key technical authority for the thermal system.

Mentor junior engineers and contribute to organizational best practices in thermal engineering.

Minimum Qualifications

Bachelor's degree in mechanical engineering, aerospace engineering, physics, or related field.

7+ years of experience in thermal engineering for aerospace systems and/or high-performance electronics.

Demonstrated experience with spaceborne thermal design, including vacuum environments, radiation heat transfer, and flight hardware qualification.

Experience with thermal modeling tools (e.g., Thermal Desktop, SINDA/FLUINT, ANSYS Icepak, or equivalent).

Knowledge of materials, coatings, and thermal interface technologies suitable for space systems.

Familiarity with environmental standards (e.g., NASA, ESA, MIL-STD) and qualification testing.

Exceptional communication skills, with a demonstrated ability to influence and guide multidisciplinary teams.

Ability and willingness to obtain and maintain a TS//SCI security clearance.

Must be a U.S. citizen or national, U.S. permanent resident (current Green Card holder), or lawfully admitted into the U.S. as a refugee or granted asylum.

Preferred Qualifications

Master's or PhD degree in mechanical engineering, aerospace engineering, physics, or related field.

Active TS//SCI clearance.

Experience supporting capture and proposal efforts for new business opportunities, including contributing technical content and solutions to winning pursuits.

Background in space-based antenna systems or similar high-power payload systems.

Experience with thermal management of high-power-density electronics such as T/R modules, phased array apertures, or laser communication terminals.

Experience with advanced cooling techniques, including loop heat pipes, vapor chambers, and liquid cooling systems.

Experience on a proliferated LEO or other high-rate satellite program.

Experience with thermal cycling / ESS / HALT-HASS-style screening, including safety-of-screen or damage accumulation analysis.

Base Pay Range For

CA applicants is $156,802.00 - $219,522.45 CO applicants is $144,179.00 - $201,849.90 WA applicants is $156,802.00 - $219,522.45 VA applicants is $156,802.00 - $219,522.45

Culture Statement

Don’t meet all desired requirements? Studies have shown that some people are less likely to apply to jobs unless they meet every single desired qualification. At Blue Origin, we are dedicated to building an authentic workplace, so if you’re excited about this role but your past experience doesn’t align perfectly with every desired qualification in the job description, we encourage you to apply anyway. You may be just the right candidate for this or other roles.

Export Control Regulations

Applicants for employment at Blue Origin must be a U.S. citizen or national, U.S. permanent resident (i.e. current Green Card holder), or lawfully admitted into the U.S. as a refugee or granted asylum.

Background Check

Required for all positions: Blue’s Standard Background Check

Required for Certain Job Profiles: Defense Biometric Identification System (DBIDS) background check if at any time the role requires one to be on a military installation

Required for Certain Job Profiles: Drivers who operate Commercial Motor Vehicles with a Gross Vehicle Weight (GVW), Gross Vehicle Weight Rating (GVWR) or combination of power unit and trailer that meets or exceeds 10,001 lbs. and/or transports placardable amounts of hazardous materials by ground in any vehicle on a public road while in commerce, may be subject to additional Federal Motor Carrier Safety Regulations including: Driver Qualification Files, Medical Certification (obtained before onboarding), Road Test, Hours of Service, Drug and Alcohol Testing, vehicle inspection requirements, CDL requirements (if applicable) and hazardous materials transportation/shipping training.

Required for certain Job Profiles: Ability to obtain and maintain Merchant Mariner Credential, which includes pre-employment and random drug testing as well as DOT physical

Benefits

Benefits include: Medical, dental, vision, basic and supplemental life insurance, paid parental leave, short and long-term disability, 401(k) with a company match of up to 5%, and an Education Support Program.

Stock Options for all regular employees (working at least 20 hours/week)

Paid Time Off: Up to four (4) weeks per year based on weekly scheduled hours, and up to 14 company-paid holidays.

Dependent on role type and job level, employees may be eligible for benefits and bonuses based on the company's intent to reward individual contributions and enable them to share in the company's results, or other factors at the company's sole discretion. Bonus amounts and eligibility are not guaranteed and subject to change and cancellation. Please check with your recruiter for more details.

Equal Employment Opportunity

Blue Origin is proud to be an Equal Opportunity/Affirmative Action Employer and is committed to attracting, retaining, and developing a highly qualified and dedicated work force. Blue Origin hires and promotes people on the basis of their qualifications, performance, and abilities. We support the establishment and maintenance of a workplace that fosters trust, equality, and teamwork. We provide all qualified applicants for employment and employees with equal opportunities for hire, promotion, and other terms and conditions of employment, regardless of their race, color, religion, sex, sexual orientation, gender identity, national origin/ethnicity, age, physical or mental disability, genetic factors, military/veteran status, or any other status or characteristic protected by federal, state, and/or local law. Blue Origin will consider for employment qualified applicants with criminal histories in a manner consistent with applicable federal, state, and local laws, including the Washington Fair Chance Act, the California Fair Chance Act, the Los Angeles Fair Chance in Hiring Ordinance, and other applicable laws. For more information on “Know Your Rights,” please see here.

Affirmative Action and Disability Accommodation

Applicants wishing to receive information on Blue Origin’s Affi tiative Plans, or applicants requiring a reasonable accommodation in order to participate in the application and/or interview process, please contact us at Please note this is a publicly managed inbox. Please do not include any personal medical information in your request.

#J-18808-Ljbffr

Worksite address

merritt island, FL, 32954, US

Who can apply

Review the original listing for work authorization, qualifications and employer requirements.

Explore related searches

Current related jobs

CNH Industrial

WhatJobs

Electrical Design Engineer

racine, WI

See pay details in description

About Us Innovation. Sustainability. Productivity. This is how we are Breaking New Ground in our mission to sustainably advance the noble …

Last received from source 2026-10-13View job

CNH Industrial

WhatJobs

Electrical Design Engineer

oak brook, IL

See pay details in description

About Us Innovation. Sustainability. Productivity. This is how we are Breaking New Ground in our mission to sustainably advance the noble …

Last received from source 2026-10-13View job

Honda Dev. and Mfg. of Am.,LLC

WhatJobs

Operational Technology Security Senior Engineer

marysville, OH

Salary not specified

What Makes a Honda, is Who makes a Honda Honda has a clear vision for the future, and it’s a joyful one.  We are looking for individuals with t…

Last received from source 2026-10-13View job

American Honda Motor Co., Inc.

WhatJobs

Mechanical Senior Design Engineer

haw river, NC

Salary not specified

What Makes a Honda, is Who makes a Honda Honda has a clear vision for the future, and it’s a joyful one.  We are looking for individuals with t…

Last received from source 2026-10-13View job

Honda Racing Corporation USA

WhatJobs

Electrical Design Contingent Engineer

santa clarita, CA

Salary not specified

Job Purpose The Electrical Design Contingent Engineer will support company projects by performing electrical design activities, collaboratin…

Last received from source 2026-10-13View job

Honda Dev. and Mfg. of Am.,LLC

WhatJobs

Mfg. Equipment Engineer (101582)

anna, OH

Salary not specified

What Makes a Honda, is Who makes a Honda Honda has a clear vision for the future, and it’s a joyful one.  We are looking for individuals with…

Last received from source 2026-10-13View job